Journal of Guangxi Normal University(Natural Science Edition) ›› 2024, Vol. 42 ›› Issue (5): 61-71.doi: 10.16088/j.issn.1001-6600.2023100901

Previous Articles     Next Articles

Parameter Optimization Design of Full-Bridge LLC Resonant Converter under Variable Load

WANG Dangshu1*, SUN Long1, DONG Zhen1, JIA Rulin1, YANG Likang1, WU Jiaju1, WANG Xinxia2   

  1. 1. School of Electrical and Control Engineering, Xi'an University of Science and Technology, Xi'an Shaanxi 710054, China;
    2. School of Science, Xi'an University of Science and Technology, Xi'an Shaanxi 710054, China
  • Received:2023-10-09 Revised:2024-02-01 Online:2024-09-25 Published:2024-10-11

PDF (PC)

36

Abstract: LLC resonant converter has some limitations in soft switching characteristics. Aiming at the problem of unstable soft switching characteristics of LLC resonant converter under variable load conditions,the soft switching constraints are derived based on ZVS/ZCS boundary. A set of parameter optimization design method based on full-bridge LLC resonant converter under variable load is proposed to improve the stability and efficiency of the system. The scheme not only considers the parameter optimization of resonant inductor,capacitor and transformer,but also fully considers the influence of load change on soft switching behavior. The working principle of the full-bridge LLC resonant converter is introduced,and the voltage gain and the impedance characteristics of the resonant network are analyzed in detail. According to the above design scheme,a 500 W vehicle charger test prototype is built and tested under laboratory conditions. The results show that the maximum efficiency of the test prototype can reach 96.36%.

Key words: LLC resonant converter, variable load, soft switch, parameter optimization, resonant network

CLC Number:  TM46
[1] 王继海. 两级式电动汽车车载充电机的研究[D]. 淮南: 安徽理工大学,2019.
[2] ZHOU K, CHEN S M, JIN M Z, et al. Research on single-phase and three-phase compatible isolated on-board charger and control technology[J]. Energies, 2022, 15(17): 6445. DOI: 10.3390/en15176445.
[3] XUE F, MA X, LI H Q, et al. High efficiency onboard charger based on two-stage circuit[J]. Journal of Electrical Engineering & Technology, 2022, 17(4): 2339-2351. DOI: 10.1007/s42835-022-01076-5.
[4] 刘林,熊兰,高迎飞. 应用于储能变流器的LLC/CLLC谐振变换器综述[J]. 电源学报,2021,19(6): 50-63. DOI: 10.13234/j.issn.2095-2805.2021.6.50.
[5] XIAO Z H, HE Z X, NING Y, et al. Optimization of LLC resonant converter with two degrees of freedom based on operation stage trajectory analysis[J]. IEEE Access, 2021, 9: 79629-79642. DOI: 10.1109/ACCESS.2021.3083100.
[6] LUO J H, WANG J H, FANG Z J, et al. Optimal design of a high efficiency LLC resonant converter with a narrow frequency range for voltage regulation[J]. Energies, 2018, 11(5): 1124. DOI: 10.3390/en11051124.
[7] REN R, LIU B, JONES E A, et al. Accurate ZVS boundary in high switching frequency LLC converter[C] // 2016 IEEE Energy Conversion Congress and Exposition(ECCE). Los Alamitos, CA: IEEE Computer Society, 2016: 1-6. DOI: 10.1109/ECCE.2016.7854813.
[8] 毛晨旭. 数字化控制的谐振式车载充电机研制[D]. 济南: 山东大学,2021. DOI: 10.27272/d.cnki.gshdu.2021.005561.
[9] 严雨阳. 全桥LLC谐振变换器的优化设计研究[D]. 南京: 南京大学,2020. DOI: 10.27235/d.cnki.gnjiu.2020.001341.
[10] 潘志杰. 混合控制全桥LLC谐振变换器的优化设计[D]. 南京: 南京航空航天大学,2013.
[11] 田风华. 基于交错并联PFC及LLC谐振变换器车载充电机的设计[D]. 杭州: 浙江工业大学,2016.
[12] 岳云涛,王成,李炳华. 全桥LLC谐振变换器稳定性分析与仿真研究[J]. 计算机仿真,2022,39(7): 161-167. DOI: 10.3969/j.issn.1006-9348.2022.07.030.
[13] 李练兵,董德林,谢朋朋,等. 基于三电平半桥LLC的充电模块研究与设计[J]. 电源技术,2019,43(7): 1212-1215, 1222. DOI: 10.3969/j.issn.1002-087X.2019.07.038.
[14] PARK H P, KIM M, JUNG J H. A comprehensive overview in control algorithms for high Switching-Frequency LLC resonant converter[J]. Energies, 2020, 13(17): 4455. DOI: 10.3390/en13174455.
[15] 赵烈,裴云庆,刘鑫浩,等. 基于基波分析法的车载充电机CLLC谐振变换器参数设计方法[J]. 中国电机工程学报,2020,40(15): 4965-4976. DOI: 10.13334/j.0258-8013.pcsee.191289.
[16] 赵子先,康龙云,于玮,等. 基于简化时域模型的CLLC直流变换器参数设计[J]. 电工技术学报,2022,37(5): 1262-1274. DOI: 10.19595/j.cnki.1000-6753.tces.210257.
[17] 朱高中,刘树林,王成,等. 改进二次型Buck-Boost变换器的研究与分析[J]. 广西师范大学学报(自然科学版),2022,40(4): 68-78. DOI: 10.16088/j.issn.1001-6600.2021072202.
[18] 饶刚,严帅,金彬,等. 100 W半桥LLC谐振变换器快速响应的控制策略设计[J]. 电子技术应用,2022,48(2): 101-106,110. DOI: 10.16157/j.issn.0258-7998.211628.
[19] 戴云飞,祝龙记. 应用于超级电容储能的开关准Z源双向DC/DC变换器研究[J]. 广西师范大学学报(自然科学版),2021,39(3): 11-19. DOI: 10.16088/j.issn.1001-6600.2020053101.
[20] 毛鹏军,丁月华,张松泓,等. 动力驱动系统锂电池单体充电特性的实验分析[J]. 电源技术,2016,40(10): 1926-1928. DOI: 10.3969/j.issn.1002-087X.2016.10.006.
[21] 徐巧玲. 开关电源之高频变压器设计[J]. 科学技术创新,2018(32): 162-163. DOI: 10.3969/j.issn.1673-1328.2018.32.093.
[22] 王国平,祝龙记. 一种交错并联对称Boost变换器[J]. 广西师范大学学报(自然科学版),2020,38(4): 11-20. DOI: 10.16088/j.issn.1001-6600.2020.04.002.
[23] 王党树,仪家安,董振,等. 单周期控制的带纹波抑制单元无桥Boost PFC变换器研究[J]. 广西师范大学学报(自然科学版),2022,40(4): 47-57. DOI: 10.16088/j.issn.1001-6600.2021082201.
[24] 石林林,祝龙记,朱红. 耦合电感升压变换器开关管应力降低的研究[J]. 广西师范大学学报(自然科学版),2016,34(2): 15-20. DOI: 10.16088/j.issn.1001-6600.2016.02.003.
[1] YAN Xiao-ming, ZHENG Zhi. Optimizing Parameters of SVM Based on Combined Bionic Algorithm [J]. Journal of Guangxi Normal University(Natural Science Edition), 2011, 29(2): 114-118.
Viewed
Full text


Abstract

Cited
  Shared   
  Discussed   
[1] LI Wenbo, DONG Qing, LIU Chao, ZHANG Qi. Fine-grained Intent Recognition from Pediatric Medical Dialogues with Contrastive Learning[J]. Journal of Guangxi Normal University(Natural Science Edition), 2024, 42(4): 1 -10 .
[2] GAO Shengxiang, YANG Yuanzhang, WANG Linqin, MO Shangbin, YU Zhengtao, DONG Ling. Multi-level Disentangled Personalized Speech Synthesis for Out-of-Domain Speakers Adaptation Scenarios[J]. Journal of Guangxi Normal University(Natural Science Edition), 2024, 42(4): 11 -21 .
[3] ZHU Gege, HUANG Anshu, QIN Yingying. Analysis of Development Trend of International Mangrove Research Based on Web of Science[J]. Journal of Guangxi Normal University(Natural Science Edition), 2024, 42(5): 1 -12 .
[4] HE Jing, FENG Yuanliu, SHAO Jingwen. Research Progress on Multi-source Data Fusion Based on CiteSpace[J]. Journal of Guangxi Normal University(Natural Science Edition), 2024, 42(5): 13 -27 .
[5] ZUO Junyuan, LI Xintong, ZENG Zihan, LIANG Chao, CAI Jinjun. Recent Advances on Metal-Organic Framework-Based Catalysts for Selective Furfural Hydrogenation[J]. Journal of Guangxi Normal University(Natural Science Edition), 2024, 42(5): 28 -38 .
[6] TAN Quanwei, XUE Guijun, XIE Wenju. Short-Term Heating Load Prediction Model Based on VMD and RDC-Informer[J]. Journal of Guangxi Normal University(Natural Science Edition), 2024, 42(5): 39 -51 .
[7] LIU Changping, SONG Shuxiang, JIANG Pinqun, CEN Mingcan. Differential Passive N-path Filter Based on Switched Capacitors[J]. Journal of Guangxi Normal University(Natural Science Edition), 2024, 42(5): 52 -60 .
[8] ZHANG Jinzhong, WEI Duqu. Fixed Time Bounded Control of PMSM Chaotic Systems without Initial State Constraints[J]. Journal of Guangxi Normal University(Natural Science Edition), 2024, 42(5): 72 -78 .
[9] TU Zhirong, LING Haiying, LI Guo, LU Shenglian, QIAN Tingting, CHEN Ming. Lightweight Passion Fruit Detection Method Based on Improved YOLOv7-Tiny[J]. Journal of Guangxi Normal University(Natural Science Edition), 2024, 42(5): 79 -90 .
[10] DU Shuaiwen, JIN Ting. A Deep Hybrid Recommendation Algorithm Based on User Behavior Characteristics[J]. Journal of Guangxi Normal University(Natural Science Edition), 2024, 42(5): 91 -100 .
Copyright © Journal of Guangxi Normal University(Natural Science Edition), All Rights Reserved.
Tel: 0773-5857325　E-mail: gxsdzkb@mailbox.gxnu.edu.cn
Powered by Beijing Magtech Co. Ltd