广西师范大学学报（自然科学版） ›› 2022, Vol. 40 ›› Issue (4): 215-226.doi: 10.16088/j.issn.1001-6600.2021062805

• 研究论文 • 上一篇    下一篇

低温下厌氧MBBR不同填料挂膜启动特性研究

解清杰1*, 王帆1, 阿琼2, 熊新港1, 常铖炜1, 姜姗1   

  1. 1. 江苏大学环境与安全工程学院,江苏镇江 212013;
    2. 西藏自治区环境科学研究所,西藏拉萨 850000
  • 发布日期:2022-08-05
  • 通讯作者: 解清杰(1973—),男,河北沧州人,江苏大学教授,博士。E-mail:xieqingjie73@163.com
  • 基金资助:
    国家自然科学基金(31971472)

Startup Characteristics in Anaerobic Moving-bed Biofilm Reactor with Different Fillers at Low Temperature

XIE Qingjie1*, WANG Fan1, A Qiong2, XIONG Xin’gang1, CHANG Chengwei1, JIANG Shan1   

  1. 1. School of the Environment and Safety Engineering, Jiangsu University, Zhenjiang Jiangsu 212013, China;
    2. Environmental Science Institute of Tibet Autonomous Region, Lasa Xizang 850000, China
  • Published:2022-08-05

PDF (PC)

272

摘要： 为了适应高寒缺氧地区特殊的环境和水质,选取厌氧MBBR(moving-bed biofilm reactor)工艺处理该地区的低温农村生活废水,通过考察Levapor海绵填料、聚乙烯K3填料和聚氨酯海绵填料在自然挂膜启动下,填料上生物膜的形态、对实际废水的处理效果、生物膜增殖速率和比呼吸速率,探究3种填料的启动特征。结果表明,生物膜先出现在K3填料的内部和多孔填料的外部,并随着反应器内溶解氧的消耗,变为黑色的厌氧生物膜;厌氧反应器对氨氮和总磷的去除效果不佳,实验末期去除率分别为-15%~8%和-10%~15%;2种多孔海绵填料对COD的去除效率更高、生物膜增殖速度更快,但寿命短并且内源比呼吸速率更高;K3填料对COD的去除率稳定上升,生物膜更新速度快而挂膜慢,但内源比呼吸速率低,在机械搅拌下寿命更长,更适合作为厌氧MBBR反应器的生物载体。

关键词: 低温, 生活废水, 厌氧, MBBR反应器, 填料, 自然挂膜, 去除率, 呼吸速率

Abstract: In order to adapt to the special environment and water quality in the high cold and anoxic area, the anaerobic MBBR process was selected to treat the low temperature rural wastewater, and the startup characteristics of three kinds of fillers were explored by investigating the morphology of biofilm on the fillers, the treatment effect on actual wastewater, the biofilm proliferation rate and the respiratory rate per gram of Levapor sponge filler, K3 filler and polyurethane sponge filler. The results showed that the biofilm appeared inside the K3 packing and outside the porous packing at first,then became black anaerobic biofilm with the consumption of dissolved oxygen in the reactor.The removal efficiency of ammonia nitrogen and total phosphorus in anaerobic reactor was low,and the removal rates were -15%-8% and -10%-15% at the last stage, respectively. The porous sponge fillers had higher COD removal rate, faster biofilm proliferation speed, but had shorter service life and higher endogenous specific respiration rate, while the removal rate of COD by K3 filler increased steadily, and K3 filler had slower biofilm formation speed because of its faster biofilm renewal speed, but had lower endogenous specific respiration rate, and longer service life under mechanical stirring, so it is more suitable for the biological carrier of anaerobic MBBR reactor.

Key words: low temperature, domestic wastewater, anaerobic, moving-bed biofilm reactor, filler, natural inoculation, removal ratio, respiratory rate

中图分类号: 

  • X703
[1] 姚修富. 西藏那曲镇城区排水系统规划的研究[D]. 成都: 西南交通大学, 2010.
[2]ZHANG X J, LIANG Y H, MA Y P, et al. Ammonia removal and microbial characteristics of partial nitrification in biofilm and activated sludge treating low strength sewage at low temperature[J]. Ecological Engineering, 2016, 93:104-111. DOI: 10.1016/j.ecoleng.2016.05.016.
[3]张琼, 包鹏, 彭永臻, 等. 低温条件对SBR工艺亚硝酸氧化菌种群结构的影响[J]. 环境工程, 2019, 37(3): 75-81. DOI: 10.13205/j.hjgc.201903014.
[4]崔萌, 马瑞芬. 污水处理厂冬季运行中生物脱氮除磷效果的分析[J]. 中国给水排水, 2016, 32(4): 72-76. DOI: 10.19853/j.zgjsps.1000-4602.2016.04.018.
[5]娄彦敏, 刘娟红, 周晓平, 等. 温度对水的粘度和扩散系数影响的研究[J]. 西南师范大学学报(自然科学版), 2009, 34(6): 34-39. DOI: 10.13718/j.cnki.xsxb.2009.06.009.
[6]韩震, 李淑萍, 朱光灿, 等. 高原地区曝气池氧传质的影响因素研究[J]. 水处理技术, 2021, 47(6): 34-38. DOI: 10.16796/j.cnki.1000-3770.2021.06.007.
[7]XIAO W T, XU G R, LI G B. Role of shear stress in biological aerated filter with nanobubble aeration: performance, biofilm structure and microbial community[J]. Bioresource Technology, 2021,325: 124714. DOI: 10.1016/J.BIORTECH.2021.124714.
[8]WANG F, XU S H, LIU L J, et al. One-stage partial nitrification and anammox process in a sequencing batch biofilm reactor: start-up, nitrogen removal performance and bacterial community dynamics in response to temperature[J]. The Science of the Total Environment, 2021, 772: 145529. DOI: 10.1016/J.SCITOTENV.2021.145529.
[9]CHANG W S, HONG S W, PARK J. Effect of zeolite media for the treatment of textile wastewater in a biological aerated filter[J]. Process Biochemistry, 2002, 37(7): 693-698. DOI: 10.1016/S0032-9592(01)00258-8.
[10]DI TRAPANI D, CHRISTENSSO M, ODEGAARD H. Hybrid activated sludge/biofilm process for the treatment of municipal wastewater in a cold climate region: a case study[J]. Water Science and Technology, 2011, 63(6). DOI: 10.2166/wst.2011.350.
[11]钟成华, 张文东, 刘鹏, 等. 包埋固定化复合菌低温下处理养猪废水研究[J]. 广西师范大学学报(自然科学版), 2011, 29(3): 52-56. DOI: 10.16088/j.issn.1001-6600.2011.03.008.
[12]BUAKAEW T, RATANATAMSKUL C. Effects of novel anaerobic baffled biofilm membrane bioreactor configurations on membrane fouling mitigation and microbial community in treating liquor condensate[J]. Bioresource Technology, 2021, 335:125310.
[13]FUCHS S, HARITOPOULOU T, WILHELMI M. Biofilms in freshwater ecosystems and their use as a pollutant monitor[J]. Water Science and Technology, 1996, 34(7/8):137-140. DOI: 10.2166/wst.1996.0612.
[14]苏鸿洋. 中国村镇分散生活污水处理技术现状[J]. 给水排水, 2015, 51(S1): 197-201. DOI: 10.13789/j.cnki.wwe1964.2015.0379.
[15]吴迪. MBBR在国内的工程应用与发展前景[J]. 中国给水排水, 2018, 34(16): 22-31. DOI: 10.19853/j.zgjsps.1000-4602.2018.16.005.
[16]黄嘉欣. MBBR与MSL组合处理农村生活污水工艺及其微生物群落研究[D]. 武汉: 华中农业大学, 2020.
[17]郑志佳,白华清,孟涛等. 低温下MBBR强化硝化原理分析和应用[J]. 中国给水排水, 2019, 35(23): 6-11. DOI: 10.19853/j.zgjsps.1000-4602.2019.23.002.
[18]王雪欣. 低温条件下多级A/O-MBBR系统生物脱氮中试实验研究[D]. 青岛: 青岛理工大学, 2020.
[19]LAURENI M, FALAS P, ROBIN O, et al. Mainstream partial nitritation and anammox: long-term process stability and effluent quality at low temperatures[J]. Water Research, 2016, 101: 628-639. DOI:10.1016/j.watres.2016.05.005.
[20]HOANG V, DELATOLL A, LAFLAMME E, et al. An investigation of moving bed biofilm reactor nitrification during long-term exposure to cold temperatures[J]. Water Environment Research, 2014, 86(1): 36-42. DOI: 10.2175/106143013X13807328848694.
[21]杨密. 填料对于MBBR工艺处理效果的影响研究[D]. 保定: 河北农业大学, 2013.
[22]高凌. 压差法测定呼吸速率(OUR)的实验研究[D]. 北京: 北京化工大学, 2019.
[23]杜甫义. 高寒缺氧地区温室型多介质人工湿地污水处理技术研究[D]. 镇江: 江苏大学, 2016.
[24]龚灵潇. 缺氧/好氧生物膜工艺处理低碳氮比生活污水的脱氮特性[D]. 北京: 北京工业大学, 2013.
[25]白旭丽. 活性污泥的内源呼吸特性分析及生物定量研究[D]. 西安: 西安建筑科技大学, 2014.
[26]陈月芳, 王岩, 安丹凤, 等. 组合移动床生物膜(MBBR)中溶解氧浓度和进水流量变化对除碳脱氮的影响[J]. 科学技术与工程, 2016, 16(4): 130-134, 140. DOI: 10.3969/j.issn.1671-1815.2016.04.023.
[27]郭新双, 苏本生, 宋英豪, 等. UASB-PACT工艺处理有机颜料废水中试研究[J]. 环境工程学报, 2016, 10(8): 4337-4342. DOI: 10.12030/j.cjee.201503162.
[28]唐琳钦, 王安柳, 宿程远, 等. 不同氮源对好氧颗粒污泥理化特性及微生物群落影响[J]. 广西师范大学学报(自然科学版), 2021, 39(2): 144-153. DOI: 10.16088/j.issn.1001-6600.2020061301.
[29]崔成武. 生物膜反应器处理农村生活污水强化措施研究[D]. 北京: 中国农业科学院, 2020.
[30]许德超, 朱婷婷, 阳立平, 等. 溶解氧对生物接触氧化+生物流化床联合脱氮效果的影响[J]. 环境污染与防治, 2020, 42(12): 1557-1562. DOI: 10.15985/j.cnki.1001-3865.2020.12.022.
[31]卢宇翔, 农志文, 宿程远, 等. 微曝气-ABR处理养猪废水及微生物群落分布[J]. 广西师范大学学报(自然科学版), 2018, 36(4): 90-98. DOI: 10.16088/j.issn.1001-6600.2018.04.012.
[32]KHOSHMANESH A, HART B T, DUNCAN A, et al. Luxury uptake of phosphorus by sediment bacteria[J]. Water Research, 2002, 36(3):774-778. DOI: 10.1016/S0043-1354(01)00272-X.
[33]KILPIMAA S, RUNTTI H, KANGAS T, et al. Removal of phosphate and nitrate over a modified carbon residue from biomass gasification[J]. Chemical Engineering Research and Design, 2014, 92(10):1923-1933. DOI: 10.1016/j.cherd.2014.03.019.
[34]马智博, 李志华, 杨成建, 等. 低氧污泥丝状菌膨胀的呼吸图谱特征分析[J]. 环境科学, 2017, 38(9): 3801-3806. DOI: 10.13227/j.hjkx.201701082.
[35]李鹏章, 李爱民, 陈博之, 等. 基于活性污泥呼吸速率的化工废水水质评价方法[J]. 化工进展, 2020, 39(6): 2472-2478. DOI: 10.16085/j.issn.1000-6613.2019-1598.
[36]江宇勤, 厉炯慧, 方治国. 多孔填料特性对生物膜形成影响[J]. 环境科学, 2020, 41(8): 3684-3690. DOI: 10.13227/j.hjkx.201912226.
[37]郭俊元, 张宇哲, 赵净. 淀粉废水生产微生物絮凝剂及发酵动力学特征[J]. 中国环境科学, 2016, 36(9): 2681-2688. DOI: 10.3969/j.issn.1000-6923.2016.09.021.
[38]LAPPALAINEN K, MANNINEN M, ALOPAEUS V, et al. An analytical model for capillary pressure-saturation relation for gas-liquid system in a packed-bed of spherical particles[J]. Transport in Porous Media, 2009, 77(1): 17-40. DOI: 10.1007/s11242-008-9259-z.
[39]董晓宇, 李志华, 杨成建, 等. 不同曝气控制方式下的活性污泥呼吸速率特征研究[J]. 工业水处理, 2017, 37(11): 50-53.
[40]崔卫华, 宋英豪, 倪文, 等. SBR系统中活性污泥内源呼吸速率的研究[J]. 环境工程学报, 2007,1(4): 123-126. DOI: 10.3969/j.issn.1673-9108.2007.04.028.
[41]钟镭, 王盟, 赵白航, 等. 载体对短程硝化生物膜特性的影响及机理探究[J]. 工业水处理, 2021, 41(2): 75-79. DOI: 10.11894/iwt.2020-0310.
[42]史晓林, 石先阳. MBBR不同填料挂膜启动及短程硝化特性研究[J]. 水处理技术, 2020, 46(6): 95-99. DOI: 10.16796/j.cnki.1000-3770.2020.06.019.
[43]李亚峰, 李旭光, 单连斌, 等. 不同填料对AA-MBBR系统处理效果及菌群多样性影响[J]. 工业水处理, 2019, 39(1): 73-77.
[44]QU J Q, YANG H C, LIU Y, et al. The study of natural biofilm formation and microbial community structure for recirculating aquaculture system[J]. IOP Conference Series: Earth and Environmental Science, 2021, 742: 012018. DOI: 10.1088/1755-1315/742/1/012018.
[45]胡小兵, 陈红伟, 聂勇, 等. 挂膜方法对生物膜特性及生化尾水深度处理的研究[J]. 中国环境科学, 2021,41(12):5710-5717.DOI: 10.19674/j.cnki.issn1000-6923.20210713.003.
[46]邹海明, 王艳, 李飞跃, 等. 2种生物膜挂膜方法对比分析及其影响因素研究[J]. 工业水处理, 2015, 35(10): 62-65.
[47]杨侃, 刘玉玲, 马昭. 奥贝尔氧化沟工艺中异养菌动力学参数测定与分析[J]. 环境工程学报, 2015, 9(10): 4731-4734.
[48]潘云浩, 孙艳霞, 宋陈光, 等. 瞬时Cu2+冲击负荷对序批式反应器脱氮性能、微生物活性和微生物群落的影响[J].中国海洋大学学报(自然科学版), 2021, 51(7): 83-91. DOI: 10.16441/j.cnki.hdxb.20200242.
[49]BAI F L, TIAN H, MA J. Advanced treatment of sewage by membrane bioreactor associate with genetically engineered autotrophic nitrifying bacteria[J]. Bioresource Technology, 2019, 288:121341. DOI: 10.1016/j.biortech.2019.121341.
[50]LIU J J, PENG Y Z, QIU S J, et al. Superior nitrogen removal and sludge reduction in a suspended sludge system within-situ enriching anammox bacteria for real sewage treatment[J]. Science of the Total Environment, 2021, 793:148669. DOI: 10.1016/J.SCITOTENV.2021.148669.
[51]LIU Y C, WILLIAM B W. Metabolic, phylogenetic, and ecological diversity of the methanogenic Archaea[J]. Annals of the New York Academy of Sciences, 2008, 1125(1): 171-189. DOI: 10.1196/annals.1419.019.
[52]CHEN S C, MUSAT N, LECHTENFELD O J, et al. Anaerobic oxidation of ethane by archaea from a marine hydrocarbon seep[J]. Nature, 2019, 568(7750): 108-111. DOI: 10.1038/s41586-019-1063-0.
[1] 肖飞, 董文明, 王维红. 基于响应面法优化污水厂脱氮工艺研究[J]. 广西师范大学学报（自然科学版）, 2021, 39(5): 210-221.
[2] 陈渊. 方形花状Bi2WO6可见光催化降解制革废水[J]. 广西师范大学学报（自然科学版）, 2016, 34(4): 60-69.
[3] 宾石玉, 林勇, 曾兰, 张妍, 杜雪松, 唐章生, 张永德, 杨慧赞, 陈忠. 低温胁迫对埃及尼罗罗非鱼肝、脾和鳃细胞形态的影响[J]. 广西师范大学学报（自然科学版）, 2015, 33(3): 123-128.
[4] 宾石玉, 曾兰, 杜雪松, 张妍, 林勇, 唐章生, 张永德, 杨慧赞, 陈忠. 低温胁迫对罗非鱼血液生理生化指标的影响[J]. 广西师范大学学报（自然科学版）, 2014, 32(4): 120-125.
[5] 杜雪松, 宾石玉, 林勇, 唐章生, 张永德, 曾兰, 杨慧赞, 陈忠. 基于ULCIZ和SIT的罗非鱼耐寒性能测定模型[J]. 广西师范大学学报（自然科学版）, 2013, 31(4): 134-139.
[6] 唐章生, 卢其西, 林勇, 宾石玉, 彭婷, 钟舒红, 甘西. 不同低温条件下吉富罗非鱼的耐受性研究[J]. 广西师范大学学报（自然科学版）, 2012, 30(1): 105-110.
[7] 钟成华, 张文东, 刘鹏, 陈建. 包埋固定化复合菌低温下处理养猪废水研究[J]. 广西师范大学学报（自然科学版）, 2011, 29(3): 52-56.
[8] 辜澜涛, 张光琦, 宋德贵. 混合菌发酵豆渣检测其粗蛋白变化情况[J]. 广西师范大学学报（自然科学版）, 2011, 29(3): 80-83.
[9] 卢其西, 林勇, 宾石玉, 唐章生, 彭婷. 罗非鱼6个家系的低温耐寒测定分析[J]. 广西师范大学学报（自然科学版）, 2011, 29(2): 104-109.
Viewed
Full text


Abstract

Cited
  Shared   
  Discussed   
No Suggested Reading articles found!
版权所有 © 广西师范大学学报（自然科学版）编辑部
地址：广西桂林市三里店育才路15号　邮编：541004
电话：0773-5857325　E-mail: gxsdzkb@mailbox.gxnu.edu.cn
本系统由北京玛格泰克科技发展有限公司设计开发