广西师范大学学报（自然科学版） ›› 2024, Vol. 42 ›› Issue (3): 27-33.doi: 10.16088/j.issn.1001-6600.2023091101

• 综述 • 上一篇    下一篇

鸡粪堆肥过程中氮素损失研究综述

曹丽娜1,2, 暴振康1,2, 王岩1,2, 李红丽1,2*   

  1. 1.郑州大学 生态与环境学院, 河南 郑州 450001;
    2.河南省环境与资源国际联合实验室(郑州大学), 河南 郑州 450001
  • 收稿日期:2023-09-11 修回日期:2023-12-26 发布日期:2024-05-31
  • 通讯作者: 李红丽(1978—), 女, 河南周口人, 郑州大学副教授, 博士。E-mail: lihonglihn@zzu.edu.cn
  • 基金资助:
    国家重点研发计划项目(2021YFD1700900)

A Review of Studies on Nitrogen Loss During the Composting of Chicken Manure

CAO Lina1,2, BAO Zhenkang1,2, WANG Yan1,2, LI Hongli1,2*   

  1. 1. College of Ecology and Environment, Zhengzhou University, Zhengzhou Henan 450001, China;
    2. Henan International Joint Laboratory of Environment and Resources(Zhengzhou University), Zhengzhou Henan 450001, China
  • Received:2023-09-11 Revised:2023-12-26 Published:2024-05-31

PDF (PC)

187

摘要： 好氧堆肥是实现鸡粪资源化处理最主要的技术手段之一。然而在鸡粪堆肥过程中氮素损失较为严重,在降低肥效的同时,还引起严重的面源污染。本文总结影响鸡粪堆肥过程氮素损失的主要原因,并综述初始C/N、初始含水率、翻堆频率、添加剂种类对鸡粪堆肥过程氮素损失的影响,得出减少鸡粪堆肥氮素损失的最适初始C/N为20～25、初始含水率为60%～65%、翻堆频率为7天1次。复合添加剂较单一添加剂更能降低堆肥过程中的氮素损失。最后提出鸡粪堆肥未来方向的研究展望,为今后进行鸡粪堆肥过程中氮素损失的研究提供理论依据。

关键词: 鸡粪, 好氧堆肥, 氮素损失, 工艺条件, 添加剂种类

Abstract: Aerobic composting is one of the main technical methods to achieve the resource utilization of chicken manure. However, nitrogen loss is serious during chicken manure composting, which not only reduces the fertilizer efficiency, but also causes severe non-point source pollution. This paper summarizes the main causes of nitrogen loss during chicken manure composting, and reviews the effects of initial C/N, initial moisture content, turning frequency, and additive types on nitrogen loss during chicken manure composting. It is concluded that the optimal initial C/N, initial moisture content, and turning frequency for reducing nitrogen loss during chicken manure composting are 20-25, 60%-65%, and once/7d, respectively. Compound additives can reduce nitrogen loss during composting more than single additives. Finally, the future research prospects of chicken manure composting are proposed. This paper provides a theoretical basis for the study of nitrogen loss during chicken manure composting.

Key words: chicken manure, aerobic composting, nitrogen loss, process conditions, type of additive

中图分类号:  S141.4

[1] 焦敏娜, 任秀娜, 何熠锋, 等. 畜禽粪污清洁堆肥:机遇与挑战[J]. 农业环境科学学报, 2021, 40(11): 2361-2371. DOI: 10.11654/jaes.2021.11.001.
[2] 芶久兰, 罗文海, 袁京, 等. 通风速率对鸡粪-烟末联合堆肥腐熟度和污染气体排放的影响[J]. 西南农业学报, 2021, 34(4): 872-879. DOI: 10.16213/j.cnki.scjas.2021.04.027.
[3] 王友玲, 邱慧珍, PHILIP G, 等. 通风方式对牛粪堆肥氨气排放与氮素转化的影响[J]. 农业机械学报, 2020, 51(11):313-320. DOI: 10.6041/j.issn.1000-1298.2020.11.034.
[4] 袁京, 刘燕, 唐若兰,等. 畜禽粪便堆肥过程中碳氮损失及温室气体排放综述[J]. 农业环境科学学报, 2021, 40(11): 2428-2438. DOI: 10.11654/jaes.2021.11.010.
[5] ZHAO S X, SCHMIDT S, QIN W, et al. Towards the circular nitrogen economy: a global meta-analysis of composting technologies reveals much potential for mitigating nitrogen losses[J]. Science of the Total Environment, 2020, 704: 135401. DOI: 10.1016/j.scitotenv.2019.135401.
[6] 秦莉, 沈玉君, 李国学, 等. 不同C/N比对堆肥腐熟度和含氮气体排放变化的影响[J]. 农业环境科学学报, 2009, 28(12): 2668-2673. DOI: 10.3321/j.issn:1672-2043.2009.12.036.
[7] 王岩. 养殖业固体废弃物快速堆肥化处理[M]. 北京: 化学工业出版社, 2005.
[8] QASIM W, LEE M H, MOON B E, et al. Composting of chicken manure with a mixture of sawdust and wood shavings under forced aeration in a closed reactor system[J]. International Journal of Recycling of Organic Waste in Agriculture, 2018, 7(3): 261-267. DOI: 10.1007/s40093-018-0212-Z.
[9] 张丽, 孙晓东, 田艳, 等. 不同种类辅料对鸡粪好氧堆肥效果的影响[J]. 环境科学与技术, 2016, 39(1): 141-146. DOI: 10.3969/j.issn.1003-6504.2016.01.026.
[10] IGORV IVIEN D C, 李昆, 李有建, 等. 微生物复合菌剂对鸡粪和蔗渣在低碳氮比好氧堆肥下的使用效果[C]// 第五届(2011)中国蛋鸡行业发展大会会刊. 扬州:《中国家禽》编辑部, 2011:236-245. DOI: 10.3969/j.issn.1005-9369.2011.04.001.
[11] 牛明芬, 王昊, 庞小平, 等. 玉米秸秆的粒径与投加量对猪粪好氧堆肥的影响[J]. 环境科学与技术, 2010, 33(S2): 159-161. DOI: 10.3969/j.issn.1003-6504.2010.12F.038.
[12] 马若男, 李丹阳, 亓传仁, 等. 碳氮比对鸡粪堆肥腐熟度和臭气排放的影响[J].农业工程学报, 2020, 36(24): 194-202. DOI: 10.11975/j.issn.1002-6819.2020.24.023.
[13] 董存明, 张曼, 邓小垦, 等. 不同碳氮比条件下鸡粪和椰糠高温堆肥腐熟过程研究[J]. 生态与农村环境学报, 2015, 31(3): 420-424. DOI: 10.11934/j.issn.1673-4831.2015.03.023.
[14] TIQUIA S M, TAM N F. Fate of nitrogen during composting of chicken litter[J]. Environmental Pollution, 2000, 110(3): 535-541. DOI: 10.1016/S0269-7491(99)00319-X.
[15] 曹云, 刘晓燕, 郭玉峰, 等. 鸡粪堆肥过程中不同初始含水率对有机质降解及脱氢酶活性的影响[J]. 环境科学学报, 2013, 34(4): 1070-1076. DOI: 10.13671/j.hjkxxb.2013.0729.
[16] LI M X, HE X S, TANG J, et al. Influence of moisture content on chicken manure stabilization during microbial agent-enhanced composting[J]. Chemosphere, 2021, 264: 128549. DOI: 10.1016/j.chemosphere.2020.128549.
[17] 蔡海森. 鸡粪与稻壳堆肥影响因素的研究[D]. 哈尔滨: 东北农业大学, 2015. DOI: 10.7666/d.y2772308.
[18] PETRICA I, ŠESTAN A, ŠESTAN I. Influence of initial moisture content on the composting of poultry manure with wheat straw[J]. Biosystems Engineering, 2009, 104(1): 125-134. DOI: 10.1016/j.biosystemseng.2009.06.007.
[19] 李晓娟, 袁京, 张晓峰, 等. 不同初始含水率对秸秆和鸡粪堆肥过程中温度、纤维素酶活性及有机质降解的影响 [J]. 农业工程学报, 2013, 29(8): 186-192. DOI: 10.3969/j.issn.1002-6819.2013.08.026.
[20] 徐鹏翔,王越,王军香, 等. 好氧堆肥中通风工艺与参数研究进展[J]. 农业环境科学学报, 2018, 37(11): 2403-2408. DOI: 10.11654/jaes.2018-0898.
[21] 顾沈怡, 钱锟, 詹永冰, 等. 不同添加剂对鸡粪堆肥中氨气和温室气体排放的影响[J]. 环境生态学, 2023, 5(2): 51-60. DOI: 10.3969/j.issn.1674-5906.2023.02.008.
[22] 李磊. 翻堆、补水、添加剂对绿化废弃物堆肥的影响[D]. 北京:北京林业大学, 2017. DOI: 10.26949/d.cnki.gblyu.2017.001096.
[23] 王博, 安昊, 张婷婷, 等. 翻堆措施对传统堆肥理化指标及微生物种群的影响[J]. 北方农业学报, 2022, 50(1): 33-43. DOI: 10.12190/j.issn.2096-1197.2022.01.05.
[24] MA Q Q, LI Y L, XUE J M, et al. Effects of turning frequency on ammonia emission during the composting of chicken manure and soybean straw[J]. Molecules, 2022, 27(2): 472. DOI: 10.3390/molecules27020472.
[25] 贾兴永. 生物炭及翻堆频率对鸡粪堆肥过程中温室气体排放的影响[D]. 中国农业大学, 2015. DOI: 10.7666/d.y2670910.
[26] CAI R, ZUO S S, CAO X H, et al. Effects of turning frequency on fermentation efficiency and microbial community metabolic function of sheep manure composting on the Qinghai-Tibet Plateau[J]. Bioresources and Bioprocessing, 2023, 10: 53. DOI: 10.1186/s40643-023-00675-y.
[27] GUO H H, GU J, WANG X J, et al. Microbial driven reduction of N2O and NH3 emissions during composting: effects of bamboo charcoal and bamboo vinegar[J]. Journal of Hazardous Materials, 2020, 390: 121292. DOI: 10.1016/j.jhazmat.2019.121292.
[28] NIE E Q, GAO D D, ZHENG G D. Effects of lactic acid on modulating the ammonia emissions in co-composts of poultry litter with slaughter sludge[J]. Bioresource Technology, 2020, 315: 123812. DOI: 10.1016/j.biortech.2020.123812.
[29] 罗一鸣, 魏宗强, 孙钦平, 等. 沸石作为添加剂对鸡粪高温堆肥氨挥发的影响[J]. 农业工程学报, 2011, 27(2): 243-247. DOI: 10.3969/j.issn.1002-6819.2011.02.041.
[30] 郑博文, 任汉儒, 黄磊, 等. 添加凹凸棒石对鸡粪堆肥理化性质和氮形态变化的影响[J]. 磷肥与复肥, 2022, 37(3): 5-8, 11. DOI: 10.3969/j.issn.1007-6220.2022.03.003.
[31] 马溪曼, 张德忠, 宋韶华, 等. 堆肥中硝化细菌的筛选及其特性研究[J]. 环境工程, 2015, 33(S1): 916-919. DOI: 10.13205/j.hjgc.2015.s1.216.
[32] 肖维伟. 禽粪便及废弃物好氧堆肥中氮转化细菌的研究[D]. 哈尔滨: 东北农业大学, 2008. DOI: 10.7666/d.y1403651.
[33] 王玉君, 任珺, 赵乾程, 等. 适用于不同作物的凹凸棒复合肥氮元素缓释效果的研究[J]. 磷肥与复肥, 2016, 31(11): 6-8. DOI: 10.3969/j.issn.1007-6220.2016.11.003.
[34] 程丰. 外源添加剂减少好氧堆肥过程氮素损失的效果研究[D]. 无锡: 江南大学, 2021.
[35] 薛文涛, 孙昊, 孙钦平, 等. 有机酸添加剂对低碳氮比条件堆肥氮素损失控制效果研究[J]. 农业环境科学学报, 2022, 41(5): 1086-1096. DOI: 10.11654/jaes.2022.05.027.
[36] 荣荣, 郑育声, 杨林生, 等. 生物炭对鸡粪堆肥过程中氨气排放的影响[J]. 江苏农业科学, 2019, 47(3): 236-240. DOI: 10.15889/j.issn.1002-1302.2019.03.056.
[37] ASADA T, OHKUBO T, KAWATA K, et al. Ammonia adsorption on bamboo charcoal with acid treatment[J]. Journal of Health Science, 2006, 52(5): 585-589. DOI: 10.1248/jhs.52.585.
[38] DIAS B O, SILVA C A, HIGASHIKAWA F S, et al. Use of biochar as bulking agent for the composting of poultry manure: effect on organic matter degradation and humification[J]. Bioresource Technology, 2010, 101(4): 1239-1246. DOI: 10.1016/j.biortech.2009.09.024.
[39] JANCZAK D, MALIN′SKA K, CZEKALA W, et al. Biochar to reduce ammonia emissions in gaseous and liquid phase during composting of poultry manure with wheat straw[J]. Waste Management, 2017, 66: 36-45. DOI: 10.1016/j.wasman.2017.04.033.
[40] 刘宁, 周嘉良, 马双双, 等. 生物炭对鸡粪好氧堆肥主要氮素形态含量影响与保氮机制[J]. 农业机械学报, 2016, 47(12): 233-239. DOI: 10.6041/j.issn.1000-1298.2016.12.028.
[41] 尹思倩, 张文明, 常馨怡, 等. 鸡粪和羊粪混合发酵对堆肥优势细菌演替和碳氮损失的影响[J]. 甘肃农业大学学报, 2023, 58(1): 193-201, 213. DOI: 10.13432/j.cnki.gsnydxxb.2023.01.023.
[42] 高鹏, 鲁耀雄, 崔新卫, 等. 不同添加剂对畜禽粪便堆肥的保氮效果[J]. 湖南农业科学, 2021(6): 38-42. DOI: 10.16498/j.hnnykx.2021.06.011.
[43] HE Y L, XING Z B, WU X D, et al. Effects of biochar on substrate degradation and ammonia emission during aerobic composting of chicken manure[J]. Agricultural Science & Technology, 2018, 19(3): 58-66. DOI: 10.16175/j.cnki.1009-4229.2018.03.008.
[44] ZHANG D, LUO W, YUAN J, et al. Effects of different additives on ammonia and greenhouse gas emissions during composting of chicken manure[J]. Waste Management, 2017, 68: 490-497. DOI: 10.1016/j.wasman.2017.07.036.
[45] LIU H A, SHI B H, LIU W W, et al. Effects of magnesium-modified biochar on antibiotic resistance genes and microbial communities in chicken manure composting[J]. Environmental Science and Pollution Research, 2023, 30: 108553-108564. DOI: 10.1007/s11356-023-29804-y.
[46] 张邦喜, 江滔, 杨仁德, 等. 生物炭和过磷酸钙投加对鸡粪-烟末-菌糠联合堆肥腐熟度及含氮气体排放的影响[J].太原理工大学学报, 2020, 51(5): 724-730. DOI: 10.16355/j.cnki.issn1007-9432tyut.2020.05.015.
No related articles found!
Viewed
Full text


Abstract

Cited
  Shared   
  Discussed   
No Suggested Reading articles found!
版权所有 © 广西师范大学学报（自然科学版）编辑部
地址：广西桂林市三里店育才路15号　邮编：541004
电话：0773-5857325　E-mail: gxsdzkb@mailbox.gxnu.edu.cn
本系统由北京玛格泰克科技发展有限公司设计开发